Concrete mixer manufacturers how to solve the cooling system failure?

在高温季节，也是车辆事故频发的季节，比如爆胎、自燃、发动机过热等等，对于混凝土赢咖7注册来说，比较容易出现散热器故障，如果赢咖7注册在行驶过程中散热器出现故障，自己又不会处理，是非常让人着急的，所以驾驶赢咖7注册的朋友要学会些快速赢咖7注册散热器故障的处理办法。当你的混凝土赢咖7注册散热器出现故障，检查以下几个部位，基本上就可以问题了。

In the high temperature season, it is also a season of frequent vehicle accidents, such as tire burst, spontaneous combustion, overheated engine, etc. for concrete mixers, it is easy to have radiator failure. If the radiator fails while the mixer is driving, it is very worrying that you can't deal with it. Therefore, friends driving mixers should learn how to quickly solve the problem of mixer cooling How to deal with the fault of the filter. When your concrete mixer radiator failure, check the following parts, basically can solve the problem.

检查保险开关：混凝土赢咖7注册是通过液压传动系统来驱动罐体的，液压油散热系统中容易出现故障的就是保险开关，因此在故障发生后，尽量一时间检查保险开关。

Check the safety switch: the concrete mixer drives the tank through the hydraulic transmission system. The safety switch is prone to failure in the hydraulic oil cooling system. Therefore, after the failure, check the safety switch as soon as possible.

检查驱动风扇：电机是整个散热系统中较为关键的部件，散热效果的好与坏，和电机的转速及运行的平稳状态有着直接的关系，它由连接车辆电瓶的电控盒直接供电，用电力驱动电机高速运转，来带走热交换器当中的额热量，给液压油降温。

Check the driving fan: the motor is a key component in the whole cooling system. The good or bad cooling effect is directly related to the speed of the motor and the stable running state. It is directly powered by the electric control box connected to the vehicle battery, and uses the electric power to drive the motor to run at high speed to take away the amount of heat from the heat exchanger and cool the hydraulic oil.
                 

检查热交换器：混凝土赢咖7注册利用液压油散热器来进行降温。热交换器上装有电机驱动风扇进行散热，让液压油正常工作，上面的机械式指针通过检测管路当中的负压，如果出现读数证明液压油滤清器可能出现堵塞，刚开始出现的时候只需要拔掉上面的橡胶指针归零，如果后面还出现读书且拔掉橡胶塞之后还不了的话，就需要更换液压油滤芯了。

Check the heat exchanger: the concrete mixer uses the hydraulic oil radiator to cool down. The heat exchanger is equipped with a motor-driven fan to dissipate heat, so that the hydraulic oil can work normally. The mechanical pointer on the top detects the negative pressure in the pipeline. If the reading indicates that the hydraulic oil filter may be blocked, just pull out the rubber pointer to zero at the beginning. If there is still a reading behind and the problem can not be solved after pulling out the rubber plug, The hydraulic oil filter element needs to be replaced.

检查热传感器：温度传感器位于热交换器的进油管上，它的作用就是检测液压油的温度，赢咖7注册散热系统发生故障后，如果确认不是保险的问题，那就检查温度传感器。

Check the heat sensor: the temperature sensor is located on the oil inlet pipe of the heat exchanger. Its function is to detect the temperature of the hydraulic oil. After the heat dissipation system of the mixer fails, if it is confirmed that it is not the insurance problem, check the temperature sensor.

检查散热器控制盒：散热控制盒监控和接受温度传感其传递过来的信号，当温度数据超过设定值后，自动接通散热风扇的电路，让空气流通降低液压油的温度，因此散热控制盒损坏后，散热系统就不能正常工作，需要及时更换，一般情况下，散热器控制盒不容易损坏。

Check the radiator control box: the radiator control box monitors and receives the signal from the temperature sensor. When the temperature data exceeds the set value, the circuit of the radiator fan is automatically connected to let the air circulate and reduce the temperature of the hydraulic oil. Therefore, after the radiator control box is damaged, the radiator system cannot work normally and needs to be replaced in time. Generally, the radiator control box is not easy to be damaged Bad.

夏季要注意混凝土自动赢咖7注册的散热系统，车辆一旦出现故障，耽误卸料，混凝土很可能会在罐体内部凝固，那就麻烦了。

In summer, we should pay attention to the heat dissipation system of the automatic concrete mixer. In case of vehicle failure and delayed discharge, the concrete is likely to solidify inside the tank, which is troublesome.

感谢您的阅读，希望以上内容对您有所帮助，如想了解更多精彩内容请点击：混凝土赢咖7注册http://www.yuanmei168.com 。

Thank you for reading, hope the above content is helpful to you, if you want to know more wonderful content, please click: concrete mixer http://www.yuanmei168.com  .