搅拌一体机加水操作有哪些特殊？
来源：http://www.yuanmei168.com/日期：2021-09-19
概述：1、搅拌车水箱的水量要经常加满，以备急用。1 The water tank of the mixer shall be filled frequently for emergency use
1、搅拌车水箱的水量要经常加满，以备急用。
1. The water tank of the mixer shall be filled frequently for emergency use.
2、水箱加水前，打开放气阀把箱内空气放掉，充气供水后及时关闭贮气筒。
2. Before adding water to the water tank, open the vent valve to release the air in the tank. After inflating and supplying water, close the air storage cylinder in time.
注意： 水箱仅在供水时加压,不要带着加压水箱在公路上行驶。
Note: the water tank is pressurized only when supplying water. Do not drive on the road with the pressurized water tank.
危险：1）在水箱没有卸压之前不可打开进水阀；2）水箱没有卸压之前不可开车行驶。
Danger: 1) do not open the water inlet valve before the water tank is depressurized; 2) Do not drive until the water tank has been depressurized.
3、水泥搅拌车冬季停放时，水箱和供水系统里，不得有剩余水。
3. When the cement mixer is parked in winter, there shall be no residual water in the water tank and water supply system.
4、卸料溜槽、加长溜槽是否需要一起使用，由具体工作位置的要求来决定。
4. Whether the discharge chute and extended chute need to be used together depends on the requirements of the specific working position.
5、满载混凝土正转时，如要反转，操纵手柄使正转停稳后，再操纵手柄反转。严禁正转过程中操纵手柄使其反转。
5. When the full load concrete rotates forward, if you want to reverse, the joystick will stop the forward rotation stably, and then the joystick will reverse. It is strictly prohibited to operate the handle to reverse it during forward rotation.
6、搅拌车司机应根据所行走路面坡度情况合理装料，避免在路上撒料，污染环境。
6. The driver of the mixer truck shall reasonably load materials according to the gradient of the road to avoid spreading materials on the road and polluting the environment.
7、搅拌筒较高并微偏向右（车后看），这种偏向当搅拌筒满载旋转时会增加,故该车在转弯时要很小心。特别是车向左转时,要更加注意,不要使搅拌筒的转速超过3r/min。
7. The mixing drum is high and slightly biased to the right (from the rear of the vehicle). This deviation will increase when the mixing drum rotates with full load, so the vehicle should be very careful when turning. Especially when the car turns left, pay more attention not to make the rotating speed of the mixing drum exceed 3R / min.
9、严禁搅拌车满载高速急转弯。
9. It is strictly prohibited to turn sharply at high speed when the mixer is fully loaded.
10、非操作人员，禁止操作。
10. Non operators are not allowed to operate.
11、下班后，将水泥搅拌车及进料斗、搅拌筒内外、出料溜槽等清洗干净。把车门锁好，转动锁紧手柄，锁牢油门手柄和伺服手柄。
11. After work, clean the cement mixer truck, feed hopper, inside and outside of the mixing drum, discharge chute, etc. Lock the door, turn the locking handle, and lock the throttle handle and servo handle firmly.
全国服务热线
点击拨打服务热线：400--555-666
